Air Transat Flight 236

Air Transat Flight 236
Air Transat Flight 236

Air Transat A330-200 C-GITS
Incident summary
Date August 24, 2001 (2001-08-24)
Type In-flight fuel exhaustion caused by fuel leak following improper maintenance
Site Lajes Air Force Base
Terceira Island, Azores, Portugal
Passengers 293
Crew 13
Injuries 18 (minor)
Fatalities 0
Survivors 306 (all)
Aircraft type Airbus A330-243
Operator Air Transat
Tail number C-GITS
Flight origin Toronto Pearson Int'l Airport
Toronto, Ontario, Canada
Destination Portela Airport, Lisbon, Portugal

Air Transat Flight 236 was an Air Transat route between Toronto, Canada and Lisbon, Portugal flown by Captain Robert Piché and First Officer Dirk De Jager. On August 24, 2001, the flight ran out of fuel over the Atlantic Ocean with 306 people (293 passengers and 13 crew) aboard. The flight crew managed to glide the unpowered aircraft to a successful emergency landing in the Azores with no loss of life.[1]

Most of the passengers on the flight were Canadians visiting Europe and Portuguese expatriates returning to visit family in Portugal.[2]

Contents

Incident

Flight TS 236 took off from Toronto at 0:52 (UTC) on Friday August 24, 2001 (local time: 8:52 p.m. (EST) on Thursday August 23, 2001) bound for Lisbon. There were 293 passengers and thirteen crew members on board. The aircraft was an Airbus A330 manufactured in 1999, configured with 362 seats and placed in service by Air Transat in April 1999. Leaving the gate in Toronto, the aircraft had 47.9 tonnes of fuel on board, 5.5 tonnes more than required by regulations.

At 05:16 UTC, a cockpit warning system chimed and warned of low oil temperature and high oil pressure on engine no. 2. There is no obvious connection between an oil temperature or pressure problem and a fuel leak. Consequently Captain Piché and co-pilot DeJager suspected these were false warnings and shared their observations with their maintenance control centre, who advised them to monitor the situation.

At 05:36 UTC, the pilots received a warning of fuel imbalance. Believing at this point that they didn't have a fuel leak, they followed a standard procedure to remedy the imbalance by transferring fuel from the port to the near-empty starboard tank.

Unknown to the pilots, the aircraft had developed a fuel leak in a fuel line to its right engine. The fuel transfer caused fuel from the operational side of the aircraft to be wasted through the leak in the engine on the other side. The leak, which averaged at 1 gallon per second, caused a higher than normal fuel flow through the fuel-oil heat exchanger (FOHE). The FOHE is designed to transfer heat from engine oil to fuel for both cooling and efficiency purposes. The increased fuel flow caused both the drop in oil temperature, as well as the rise in oil pressure that the pilots had observed earlier.[3]

Air Transat Flight 236 is located in North Atlantic
Azores
Toronto
Lisbon
North Atlantic

At 05:45 UTC, the pilots decided to divert to Lajes Air Base in the Azores, still unsure if they really had a fuel leak or not. They declared a fuel emergency with Santa Maria Oceanic air traffic control three minutes later.

At 06:13 UTC, while still 135 miles (217 km) from Lajes,[4] engine no. 2 on the right wing flamed out because of fuel starvation. Captain Piché ordered full thrust from the remaining operational engine, and the plane descended to 33,000 feet (10,000 m), unable to stay at its 39,000 feet (12,000 m) cruising altitude with only one engine operating. Ten minutes later, the crew sent a Mayday to Santa Maria Oceanic air traffic control.

Thirteen minutes later, engine no. 1 also flamed out at while the aircraft was still approximately 65 nautical miles (120 km) from Lajes Air Base.[5] Without engine power, the aircraft not only lost thrust, but also its primary source of electrical power. The emergency ram air turbine was deployed automatically to provide essential power for critical sensors and instruments to fly the aircraft. However the aircraft lost its main hydraulic power which operates the flaps, brakes, and spoilers.

Military air traffic controllers who were tracking the aircraft on their radar system guided the aircraft to the airport. While Piché flew the plane, DeJager monitored its descent rate — around 2000 feet (600 metres) per minute — and calculated that the plane had about 15 to 20 minutes left before they had to ditch the plane in the water. The crew sighted the air base a few minutes later. Piché had to execute a series of 360 degree turns to lose speed and altitude. Although they successfully lined up with Runway 33, they faced a new danger. The plane was on a final descent, going faster than optimal. Although they had unlocked the slats and deployed the landing gear, the airspeed was still too high. Additionally, the aircraft would be unable to use its thrust reversers to slow the plane during the landing.

At 06:45 UTC, the plane touched down hard 1,030 feet (310 m) down Runway 33 at a speed of approximately 200 knots (370 km/h), instead of the 170 knots (310 km/h) recommended for an unpowered landing. The aircraft bounced back into the air, but touched down again 2,800 feet (850 m) from the approach end of the runway and came to a stop 7,600 feet (2,300 m) from the approach end of the 10,000 feet (3,000 m) runway. With the operation of the emergency brakes, eight tires burst. Fourteen passengers and two crew members suffered minor injuries during the evacuation of the aircraft. Two passengers suffered serious but not life-threatening injuries.

The favourable outcome was partly attributable to the flight being rerouted at the last minute via a more southerly air corridor across the Atlantic than initially planned, which brought the aircraft within range of the Azores.

Investigation

The Portuguese Gabinete de Prevenção e Investigação de Acidentes com Aeronaves (GPIAA) investigated the incident along with Canadian and French authorities.[2]

The investigation revealed that the cause of the incident was a fuel leak in the number two engine, caused by an incorrect part installed in the hydraulics system by Air Transat maintenance staff. The part, which was adapted from a similar engine, did not maintain adequate clearance between the hydraulic lines and the fuel line. This allowed vibration in the hydraulic lines to degrade the fuel line and cause the leak. Air Transat accepted responsibility for the incident and was fined CAD 250,000 by the Canadian government, which as of 2009 is still the largest fine in Canadian history.[2]

Although pilot error was listed as one of the lead causes for the incident, it was the skill of the pilots, and of the military Air Traffic Controller in service at the time, 1st Sgt. José Ramos,[6] that allowed the flight to land without fuel, causing only minor injuries to the passengers and minor damage to the airplane, which is still in service. The pilots returned to a heroes' welcome from the Québec press.

The incident also led to the Direction Générale de l'Aviation Civile (DGAC) and Federal Aviation Administration (FAA) issuing an Airworthiness Directive,[7] forcing all operators of Airbus model A318-100, A319-100, A320-200, A321-100, and A321-200 Series aeroplanes; and Model A320-111 aeroplanes to change the flight manual, stressing that crews should check that any fuel imbalance is not caused by a fuel leak before opening the cross-feed valve. The French Airworthiness Directive (AD) required all airlines operating these Airbus models to make revisions to the Flight Manual before any further flights were allowed. The FAA gave a 15-day grace period before enforcing the AD. Airbus also modified its computer systems; the on-board computer now checks all fuel levels against the flight plan. It now gives a clear warning if more fuel is being lost than the engines can consume. Rolls-Royce also issued a bulletin advising of the incompatibility of the affected engine parts.

Dramatization

A documentary in the Mayday television series (also known as Air Crash Investigation and as Air Emergency) was made about this incident. The episode's name is "Flying on Empty".

MSNBC also produced a report on the incident, entitled "A Wing and A Prayer".

The story of Robert Piché is depicted in the 2010 French Canadian biographical drama film Entre ciel et terre ("Between Sky and Earth") culminating with the events on Flight 236.[8] Captain Piché is portrayed by both Genie Award-winning actor Michel Côté and his son Maxime LeFlaguais.

See also

References

External links

Coordinates: 42°43′59″N 23°04′59″W / 42.733°N 23.083°W / 42.733; -23.083


Wikimedia Foundation. 2010.

Игры ⚽ Поможем решить контрольную работу

Look at other dictionaries:

  • Air-Transat-Flug 236 — Air Transat Flug 236 …   Deutsch Wikipedia

  • Air Transat — Infobox Airline airline=Air Transat logo=AirTransatLogo.png logo size=200px fleet size=18 destinations= 90 IATA=TS ICAO=TSC callsign=TRANSAT parent=Transat A.T. Inc. founded=1986 headquarters=Montreal, Quebec key people=Allen B Graham (Chairman… …   Wikipedia

  • Vol 236 Air Transat — Vol 236 Air Transat …   Wikipédia en Français

  • Air Transat — OACI TSC Indicativo TRANSAT Fundación 1986 Aeropuerto principal Aeropu …   Wikipedia Español

  • Air Transat — Codes AITA OACIL Indicatif d appel TS T …   Wikipédia en Français

  • Рейс 236 Air Transat — 236 Air Transat Air Transat A330 200 C GITS …   Википедия

  • Air Transat — Air Transat …   Википедия

  • Air France Flight 358 — Vol 358 Air France Carcasse de l’avion après l’accident Le vol Air France 358 était un vol de passagers en partance de l’aéroport Roissy Charles de Gaulle (terminal 2F) et devant arriver au terminal 3 de l’aéroport international Pearson de… …   Wikipédia en Français

  • Air-Canada-Flug 143 — C GAUN b …   Deutsch Wikipedia

  • Ethiopian Airlines Flight 961 — Artist rendition of the moment the left wing struck the water. Hijacking summary Date November 23, 1996 …   Wikipedia

Share the article and excerpts

Direct link
Do a right-click on the link above
and select “Copy Link”