Pressure-fed cycle (rocket)


Pressure-fed cycle (rocket)

The pressure-fed cycle is a class of rocket engine designs. A separate gas supply, usually helium, pressurizes the propellant tanks to force fuel and oxidizer to the combustion chamber. To maintain adequate flow, the tank pressures must exceed the combustion chamber pressure.

Pressure fed engines have simple plumbing and lack complex and often unreliable turbopumps. A typical startup procedure begins with opening a valve, often a one-shot pyrotechnic device, to allow the pressurizing gas to flow through check valves into the propellant tanks. Then the propellant valves in the engine itself are opened. If the fuel and oxidizer are hypergolic, they burn on contact; non-hypergolic fuels require an igniter. Multiple burns can be conducted by merely opening and closing the propellant valves as needed. They can be operated electrically, or by gas pressure controlled by smaller electrically operated valves.

Care must be taken, especially during long burns, to avoid excessive cooling of the pressurizing gas due to adiabatic expansion. Cold helium won't liquify, but it could freeze a propellant, decrease tank pressures, or damage components not designed for low temperatures. The Apollo Lunar Module descent propulsion system was unusual in storing its helium in a supercritical but very cold state. It was warmed as it was withdrawn through a heat exchanger from the ambient temperature fuel.

Spacecraft attitude control and orbital maneuvering thrusters are almost universally pressure-fed designs. Examples include the Reaction Control (RCS) and Orbital Maneuvering (OMS) engines of the Space Shuttle orbiter; the RCS and Service Propulsion System (SPS) engines on the Apollo Command/Service Module; and the RCS, ascent and descent engines on the Apollo Lunar Module.

Some upper launcher stages also use pressure-fed engines. These include the AJ-10 second stage of the Delta II launch vehicle, the Agena and the Kestrel engine of the Falcon-1 by Space-X.

Pressure-fed engines have practical limits on propellant pressure and flow rate that make them unsuitable when high thrust is needed. The lower stages of launch vehicles use solid fuel and pump-fed liquid fuel engines instead.

ee also

*Gas-generator cycle
*Expander cycle
*Staged combustion cycle

External links

* [http://www.aero.org/publications/crosslink/winter2004/03_sidebar3.html Rocket power cycles]


Wikimedia Foundation. 2010.

Look at other dictionaries:

  • Staged combustion cycle (rocket) — Staged combustion rocket cycle. Usually, all of the fuel and a portion of the oxidizer are fed through the pre burner (fuel rich) to power the pumps. An oxygen rich circuit is possible also, but less common because of the metallurgy required. The …   Wikipedia

  • Gas-generator cycle (rocket) — The gas generator cycle (also known as open cycle) is a power cycle of a bipropellant rocket engine. Some of the propellant is burned in a gas generator and the resulting hot gas is used to power the engine s pumps. The gas is then… …   Wikipedia

  • Expander cycle (rocket) — The expander cycle is a power cycle of a bipropellant rocket engine meant to improve the efficiency of fuel delivery.In an expander cycle, the fuel is heated before it is combusted, usually with waste heat from the main combustion chamber. As the …   Wikipedia

  • Rocket engine — RS 68 being tested at NASA s Stennis Space Center. The nearly transparent exhaust is due to this engine s exhaust being mostly superheated steam (water vapor from its propellants, hydrogen and oxygen) …   Wikipedia

  • Cryogenic rocket engine — Vulcain engine of Ariane 5 rocket …   Wikipedia

  • Gas core reactor rocket — Gas core reactor rockets are a conceptual type of rocket that is propelled by the exhausted coolant of a gaseous fission reactor. The nuclear fission reactor core may be either a gas or plasma. They may be capable of creating specific impulses of …   Wikipedia

  • Nuclear thermal rocket — Sketch of nuclear thermal rocket …   Wikipedia

  • Nuclear electric rocket — In a nuclear electric rocket, nuclear thermal energy is changed into electrical energy that is used to power one of the electrical propulsion technologies. Technically the powerplant is nuclear, not the propulsion system, but the terminology is… …   Wikipedia

  • Nuclear salt-water rocket — A nuclear salt water rocket (or NSWR) is a proposed type of nuclear thermal rocket designed by Robert Zubrin that would be fueled by water bearing dissolved salts of Plutonium or U235. These would be stored in tanks that would prevent a critical… …   Wikipedia

  • Nuclear photonic rocket — In a nuclear photonic rocket, a nuclear reactor would generate such high temperatures that the blackbody radiation from the reactor would provide significant thrust. The disadvantage is that it takes a lot of power to generate a small amount of… …   Wikipedia


Share the article and excerpts

Direct link
Do a right-click on the link above
and select “Copy Link”

We are using cookies for the best presentation of our site. Continuing to use this site, you agree with this.