Flying car (aircraft)

For other uses, see: Flying car. For non-real (fictional) flying cars, see: Flying car (fiction).

Moller Skycar M400 to the right, next to older Moller models

The Waterman Aerobile at the Smithsonian

A flying car or roadable aircraft is an aircraft that can also travel along roads. All the working examples have required some manual or automated process of conversion between the two modes of operation.

A slightly different concept that is sometimes referred to as a "flying car", particularly in science fiction, is that of an aircraft that would be practical enough for every-day travel, but would not necessarily be drivable on the roads.^[1]

History

Early experiments

Glenn Curtiss, the chief rival of the Wright brothers, was the first to design a flying car. His large, three-wing Curtiss Autoplane was able to hop, not fly.^[2]

In 1926, Henry Ford displayed an experimental single-seat aeroplane that he called the "sky flivver". The project was abandoned two years later when a distance-record attempt flight crashed, killing the pilot.^[3] The Flivver was not a flying car at all, but it did get press attention at the time, exciting the public that they would have a mass produced affordable airplane product that would be made, marketed, sold, and maintained just like an automobile. The airplane was to be as commonplace in the future as the Model T of the time.

The first flying car to actually fly was built by Waldo Waterman. Waterman was associated with Curtiss while Curtiss was pioneering naval aviator on North Island on San Diego Bay in the 1910s. On March 21, 1937, Waterman's Arrowbile first took to the air.^[4] The Arrowbile was a development of Waterman's tailless aircraft, the Whatsit.^[5] It had a wingspan of 38 feet (11 m) and a length of 20 feet 6 inches (6.25 m). On the ground and in the air it was powered by a Studebaker engine. It could fly at 112 mph (180 km/h) and drive at 56 mph (90 km/h).

Post-war development

In the 1950s, the western world was recovering from World War II and everything seemed possible.^{[citation needed]} The flying car was a vision of transportation in the 21st century, and a common feature of science fiction futures.

Although several designs (such as the Convair flying car) have flown, none have enjoyed commercial success, and those that have flown are not widely known about by the general public. The most successful example, in that several were made and one is still flying, is the 1949 Taylor Aerocar. One notable design, Henry Smolinski's Mizar, made by mating the rear end of a Cessna Skymaster with a Ford Pinto, disintegrated during test flights, killing Smolinski and the pilot.

In the 1950s, Ford Motor Company performed a serious feasibility study for a flying car product. They concluded that such a product was technically feasible, economically manufacturable, and had significant realistic markets. The markets explored included ambulance services, police and emergency services, military uses, and initially, luxury transportation. Some of these markets are now served by light helicopters. However, the flying car explored by Ford was projected to be at least fiftyfold less expensive.^{[citation needed]}

When Ford approached the U.S. Federal Aviation Administration (FAA) about regulatory issues, the critical problem was that the (then) known forms of air traffic control were inadequate for the volume of traffic Ford proposed. At the time, air traffic control consisted of flight numbers, altitudes and headings written on little slips of paper and placed in a case. Quite possibly computerized traffic control, or some form of directional allocation by altitude could resolve the problems. Other problems would also need to be resolved in some ways, however, including intoxicated pilots or pilots that drive/fly without a license. Standards would have to be agreed upon by the international community, such as air miles being translated to nautical miles and not affecting the reading of the odometer. Furthermore, there would be serious concerns among the public in built up urban areas, that malfunctioning or incorrectly operated flying cars could crash into houses, shopping districts or pedestrian areas, severely damaging buildings or killing civilians.^{[citation needed]}

Historic flying cars and roadable aircraft

Jess Dixon's flying automobile c. 1940

• Skroback Roadable Airplane - 1934 Tested only on the ground, this vehicle used 3 pairs of short wings in tandem.
• Autogiro Company of America AC-35 – 1936 One example of a roadable autogyro demonstrated for the Bureau of Air Commerce.
• Autoplane - 1936
• Gwinn Aircar - 1938
• Waterman Aerobile – 1937 two examples in museums as of 2004
• Airmaster - 1944
• BelGeddes - 1945
• Fulton Airphibian – 1946, one example in Canada Aviation Museum.
• Convair Model 118 – 1947, ConvAirCar, Two prototypes built.
• Aerocar – 1949, one example still flying as of 2006; two examples in museums
• Aerauto PL.5C – early 1950s
• Bryan Autoplane – 1953, a series of folding wing roadable aircraft based on the Erco Ercoupe.
• Ford Volante - 1958
• Curtiss-Wright VZ-7 – 1958, one example in United States Army Aviation Museum.
• Chrysler VZ-6 – 1959
• Piasecki VZ-8 Airgeep – 1962
• Wagner Aerocar – 1965, The Wagner FJ-V3 Aerocar was a protoype 4-place flying automobile. The vehicle used counter-rotating rotor helicopter technology for flight.
• AVE Mizar – 1973, Cessna Skymaster/Ford Pinto hybrid. Crashed, killing developer.
• AviAuto - 1990's

Modern development

There is an active movement in the search for a practical flying car. Several conventions are held yearly to discuss and review current flying car projects. Two notable events are the Flying Car forum held at the world-famous EAA Airventure at Oshkosh, Wisconsin, and the Society of Automotive Engineers (SAE) conventions held at various cities.

The American Defense Advanced Research Projects Agency, has shown a interest in the concept with a sixty five million dollar program to develop a four place roadable aircraft by 2015. The vehicle is required to take off vertically, and have a 280 mile range. Terrafugia, AAI Corporation, and other Textron companies have been awarded the contract.^[6]

Flying cars fall into one of two styles; integrated (all the pieces can be carried in the vehicle), or modular (the pieces to fly are left at the airport when the vehicle is driven).

Current development examples

A number of companies are developing vehicles, although few have demonstrated a full-sized vehicle capable of free flight. These include:

• The Parajet Skycar utilises a paramotor for propulsion and a parafoil for lift. The main body consists of a modified dune buggy. It has a top speed of 80 mph (130 km/h) and a maximum range of 180 miles (290 km) in flight. On the ground it has a top speed of 112 mph (180 km/h) and a maximum range of 249 miles (401 km). Parajet flew and drove its prototype from London to Timbuktu in January 2009. The company intends to produce a commercial version which would cost £50,000.
• The Wernicke SkyCar The Wernicke four seat AirCar was designed during the 1990s and involves narrow wing technology to enable it to transition between flying and highway use without any alterations whatsoever. Motive power on the ground and in the air is by hydraulic drive and therefore no added gearbox is required. Prototype one-third scale models were extensively wind tunnel and flight tested.^{[citation needed]}
• Terrafugia, a private company founded by MIT graduates, has developed the Transition,^[7] a roadable aircraft that the company describes as a "Personal Air Vehicle". The aircraft can fold its wings in 30 seconds and drive the front wheels, enabling it to operate as a traditional road vehicle and as a general aviation aeroplane. The Transition "Personal Air Vehicle" will be released to customers in late 2011. An operational prototype was displayed at Oshkosh in 2008^[8] and its first flight occurred on 2009-03-05.^[9] The estimated purchase price is $250,000.^[10] Owners will drive the car from their garage to an airport where they will then be able to fly within a range of 100 mi (160 km) to 500 mi (800 km). It will carry two people plus luggage and its Rotax 912S engine operates on a single tank of premium unleaded gas.^[11]
• StrongMobile's Magic Dragon Aircar^[12] has been developed by retired Air Force pilot-engineer Rich Strong over a 50-year period. The design uses an automobile-type lifting body fuselage and automotive suspension. Flight propulsion uses a front-mounted ducted fan with side outlets. Automatic conversion uses a combination of folding and swinging to stow the wings into the body. The current design envisions a core market of frequent regional business travellers whose time savings make using the StrongMobile virtually revenue neutral.
• LaBiche Aerospace's LaBiche FSC-1^[13] is a developmental prototype Flying Car and is an example of a practical flying car capable of utilizing today's automotive and aviation infrastructure to provide true "door-to-door" travel^{[citation needed]}. The vehicle can be parked in any garage or parking space available for cars. The FSC-1 is the first known vehicle capable of automatic conversion from aircraft to car at the touch of a button. LaBiche has flown a 1/10 scale model, tested a ¼-scale model and is currently finishing the FSC-1 prototype for road and air testing, as of 2006. Currently, the FSC-1 requires a pilot and driver's license to operate. However, upon approval from the FAA, development is underway for utilizing a new satellite-navigation "hands free" flight system to travel from airport to airport that will eliminate the need for a pilot's license^{[citation needed]}. Numerous safety systems and fail safes are also employed on the FSC-1, such as a recovery parachute. No news has been added to the website since September, 2007.
• The Haynes Aero Skyblazer^[14] is a development stage vehicle that uses a single turbofan engine to provide thrust in the air and to generate electricity to power electric motors for ground travel. In "car mode", a patented mechanism allows the wings to fold into the body of the vehicle, which is designed to fit into a single car garage and regular parking space. In "aircraft mode" the vehicle will have STOL capabilities and be able to use almost any public use airfield. It is expected to have a top speed of 400 mph (640 km/h) and a range of 830 miles (1,340 km). The skyblazer team has completed wind tunnel, stability and control testing and flown a 1/6 scale model.
• The Milner AirCar^[15] is an advanced composite four-door, four-passenger roadable aircraft (flying car) with foldable main wing at the rear and foldable canard in the front. The AirCar has a wingspan of 28 ft (8.5 m), maximum gross weight of 3,000 lb (1,400 kg) and a total of 300 hp (220 kW) from dual ducted fans. Cruise airspeed and range are expected to be 200 mph (322 km/h) for 1,000 miles (1,600 km). After landing the wings fold to a width of 7 ft (2.1 m) so the vehicle can drive on public roads. A drive-able, but non-flyable prototype is complete.
• The Moller Skycar M400^[16] is a prototype personal VTOL (vertical take-off and landing) aircraft that some refer to as a flying car, although it cannot be driven as an automobile. However, the Skycar is a good demonstration of the technological barriers to developing the VTOL flying car. Moller International continues to develop the Skycar M400, which is powered by four pairs of in-tandem Wankel rotary engines, and is approaching the problems of satellite-navigation, incorporated in the proposed Small Aircraft Transportation System. Moller also advises that, currently, the Skycar would only be allowed to fly from airports & heliports. Moller has been developing VTOL craft since the late 1960s, but no Moller vehicle has ever achieved free flight out of ground effect. The proposed Autovolantor model has an all-electric version powered by Altairnano batteries.^[17]
• Urban Aeronautics' X-Hawk^[18] is a VTOL aircraft which operates much like a tandem rotor helicopter, however it doesn't have the exposed rotors which make helicopters dangerous for personal use. This is accomplished by containing the rotors in large 'ducts' which make up most of the body of the craft; the requisite decrease in rotor size also decreases fuel efficiency. The X-Hawk is being promoted for rescue and utility functions. It is scheduled to be available for about $3 million around 2010.
• MACRO Industries – SkyRider^[19] is a prototype of a flying car developed by MACRO Industries, Inc. Lighter than the Moller Skycar.
• MotoPOD LLC,^[20] advocates the combined use of airplanes and motorcycles to achieve door-to-door transportation. The company has developed a Motorcycle Pod that allows pilots to carry a street-legal motorcycle beneath their airplane. After landing, it takes only a few minutes to remove the motorcycle, unfold the handlebars and ride away. The company believes this modular solution will appeal to pilots who currently enjoy airplanes and motorcycles separately.
• PAL-V Europe BV: the PAL-V ONE^[21] is a hybrid of a gyrocopter with a car. It has 3 wheels and a top speed of 200 km/h (124 mph) on land and air. It can run on petrol, biodisel or bio-ethanol and will cost $US75 000. The vehicle has a very short take of and vertical landing capability. At less than 70 decibels it is quieter than a helicopter due to the slower rotation of the main rotor. The PAL-V ONE has one seat.
• The Volante Aircraft.^[22] This is a modular design, in development. The flying module attaches to the driving module for flight, while when detached, the driving module is roadable.
• The Wolff AeroCycle.^[23] is a motorcycle that can have the airplane parts attached in order to fly, and then detached to drive on the road.
• The Switchblade,^[24] by SAMSON MOTORWORKS LLC is a three-wheel concept with scissor wings. First introduced at AirVenture 2008, the Switchblade is to utilize a single Wankel rotary engine and ducted fan to keep the propeller out of harm's way on the ground. The wheels and propeller are to be powered by the same engine, but wheel-power only to be utilized on the ground. Development is ongoing at DAR Corp of Lawrence, Kansas, with flying prototype targeted for 2010. A predicted top speed of 110 mph (180 km/h) on the ground is nearly as fast as the anticipated 150 mph (240 km/h) in the air. No parts are left at the airport after conversion from aircraft to ground vehicle, as the main wing and tail retract into the vehicle body. The vehicle leans into the turns on the ground, to impart the feeling of being 'flown' on the ground as well.
• The I-TEC 'Maverick' Flying Dune Buggy was designed as an off-road vehicle that could unfurl an advanced parachute and then travel by air over impassable terrain when roadways were no longer usable. Designed by the Indigenous People’s Technology and Education Center (I-TEC) of Florida, a Christian ministry, the 1100-pound 'Maverick' vehicle is powered by a 128 hp (95 kW) engine that can also drive a five-bladed pusher propeller. It was initially conceived of in order to help minister to remote Amazon rainforest communities, but will also be marketed for visual pipeline inspection and other similar activities in desolate areas or difficult terrain.^[25]
• The Aerocar 2000 is a modular design currently in development by Ed Sweeney, owner of one of Moulton Taylor's Aerocars.
• The Plane Driven PD-1 Roadable Glastar is a modification to the Glastar Sportsman GS-2 to make a practical roadable aircraft. The approach is novel in that it uses a mostly stock aircraft with a modified landing gear "pod" that carries the engine for road propulsion. The wings fold along the side, and the main landing gear and engine pod slide aft in driving configuration to compensate for the rearward center of gravity with the wings folded, and provide additional stability for road travel.^[26]
• The iCar 101 has extensible cylindrical wings which spin to provide lift due to the Magnus effect.^[27]
• The Scaled Composites Model 367 BiPod is a developmental hybrid using joined fuselages, and twin combustion engines powering four 15 kW electric propellers.

Gallery

• 

  Taylor Aerocar III

• 

  Fulton Airphibian FA-3-101

• 

  Terrafugia Transition

• 

  Maverick Flying car

• 

  PD-1 Roadable car

See also

• Flying car (fiction)
• Future of the car
• Personal Air Vehicle
• CarterCopter
• Motorcycle Pod
• Intermodal passenger transport

References

1. ^ http://www.theregister.co.uk/2007/10/10/transition_flying_car_quite_realistic/
2. ^ Thomas Vinciguerra (April 11, 2009). "Flying Cars: An Idea Whose Time Has Never Come". New York Times. http://www.nytimes.com/2009/04/12/weekinreview/12vinciguerra.html. 
3. ^ Popular Science: Looking back at Henry Ford's Flivver: A plane-car for the man of average means, December 2001
4. ^ "Plane Sheds Wing To Run On Ground" Popular Science, May 1937
5. ^ "Tailless Flivver Plane Has Pusher Propeller" Popular Science,May 1934, rare photos in article
6. ^ "Terrafugia Tapped for DARPA Project". http://www.eaa.org/news/2010/2010-12-02_terrafugia.asp. Retrieved 6 December 2010. 
7. ^ "Terrafugia, Inc". Terrafugia.com. http://www.terrafugia.com/. Retrieved 2010-10-07. 
8. ^ "Terrafugia ready for road, flight testing". Airventure.org. 2008-08-02. http://www.airventure.org/news/2008/7sat2/terrafugia.html. Retrieved 2010-04-15. 
9. ^ Haines, Thomas B.. "AOPA Online: First roadable airplane takes flight". Aopa.org. http://www.aopa.org/aircraft/articles/2009/090319terrafugia.html. Retrieved 2010-04-15. 
10. ^ "Terrafugia - Transition FAQ". http://www.terrafugia.com/faq.html#FAQ8. 
11. ^ "mybizagent.com". mybizagent.com. http://www.mybizagent.com/?cat=26. Retrieved 2010-10-07. 
12. ^ "StrongMobile "Magic Dragon" Flying Car Project". Strongware.com. http://www.strongware.com/dragon. Retrieved 2010-10-07. 
13. ^ LaBiche Aerospace: The FSC-1
14. ^ "Skyblazer Flying Car – a Roadable aircraft". Haynes-aero.com. http://www.haynes-aero.com. Retrieved 2010-10-07. 
15. ^ "Transforming Transportation". Milner Motors. http://www.milnermotors.com. Retrieved 2010-10-07. 
16. ^ http://www.moller.com
17. ^ [1]^{[dead link]}
18. ^ "Urban Aeronautics". Urbanaero.com. http://www.urbanaero.com/Urban_Main.htm. Retrieved 2010-10-07. 
19. ^ "SkyRider Main Page". Macroindustries.com. http://www.macroindustries.com/website/files/skyrider/_1024/index_main.htm. Retrieved 2010-10-07. 
20. ^ "MotoPOD LLC Homepage". Motorcyclepilot.com. http://www.MotorcyclePilot.com. Retrieved 2010-10-07. 
21. ^ "PAL-V". PAL-V. http://www.pal-v.com/. Retrieved 2010-10-07. 
22. ^ "Flying Car from". Volante Aircraft. http://www.volanteaircraft.com. Retrieved 2010-10-07. 
23. ^ "The Wolff AeroCycle". The Wolff AeroCycle. http://www.wolffaerocycle.com/. Retrieved 2010-10-07. 
24. ^ "Switchblade". Samsonmotorworks.com. http://www.samsonmotorworks.com. Retrieved 2011-04-25. 
25. ^ Logan Ward, 10 Most Brilliant Innovators of 2009: I-TEC’s Flying Dune Buggy, Popular Mechanics, November 2009. Retrieved 25 October 2009.
26. ^ Budd Davisson (October 2010). "The PD-1 Roadable Glastar". Sport Aviation. 
27. ^ "About the iCar 101". Icar-101.com. http://www.icar-101.com/icar/index.php?/eng/About-iCar-101. Retrieved 2011-04-25. 

External links

• Roadable Times – pictures and descriptions of over 70 designs of flying cars and roadable aircraft, past and present
• Waterman Aerobile at the Smithsonian
• Flying cars in 25 years (BBC News Online)
• How Flying Cars Will Work from HowStuffWorks
• Tales of Future Past
• X-Hawk from HowStuffWorks
• Sky Divers – slideshow by The First Post
• Future Flying Cars
• Flying Car "iCar 101" with Magnus effect wings
• Flying Cars & Airborne Oddities – slideshow by Life magazine
• Transition Flying Car video on TED