Magnetic cartridge

Magnetic cartridge
An Audio Technica AT-F3 MC cartridge

A magnetic cartridge is a transducer used for the playback of gramophone records on a turntable or phonograph. It converts mechanical vibrational energy from a stylus riding in a spiral record groove into an electrical signal that is subsequently amplified and then converted back to sound by a loudspeaker system.

Contents

History

The first widely used type of electric phonograph pickup was commercially introduced in 1925. It was magnetic, but its resemblance to later magnetic cartridges is remote: it employed a bulky horseshoe magnet and the same imprecisely mass-produced single-use steel needles used by non-electronic record players since the 1890s. It had a tracking weight measured in ounces, not grams. By the late 1930s this design had been superseded by a comparatively lightweight piezoelectric "crystal" or ceramic type, but the use of short-lived metal needles was standard until after World War II, when precision-ground and conveniently long-lasting styli made of osmium or sapphire began to come into wide use. After the introduction of the vinyl LP "album" in 1948 and the vinyl 45 rpm "single" in 1949, the use of sapphire or diamond styli for these new "microgroove" formats was practically universal. Initially, the styli were simply used in smaller, lighter piezoelectric cartridges of the general type used in inexpensive self-contained portable record players throughout the vinyl era and in most of the "retro" units now being made, but a new generation of lightweight and highly compliant magnetic cartridges came into use among audiophiles in the 1950s and their refined descendants are the most common type of pickup in use today.

Types

In high-fidelity systems, crystal and ceramic pickups have been replaced by the magnetic cartridge, using either a moving magnet or a moving coil.

Compared to the crystal and ceramic pickups, the magnetic cartridge usually gives improved playback fidelity and reduced record wear by tracking the groove with lighter pressure. Magnetic cartridges use lower tracking forces and thus reduce the potential for groove damage. They also have a lower output voltage than a crystal or ceramic pickup, in the range of only a few millivolts, thus requiring greater amplification.

Moving Magnet (MM) and Moving Iron (MI) cartridges

In a moving magnet cartridge, the stylus cantilever carries a tiny permanent magnet, which is positioned between two sets of fixed coils (in a stereophonic cartridge), forming a tiny electromagnetic generator. As the magnet vibrates in response to the stylus following the record groove, it induces a tiny current in the coils.

Because the magnet is small and has little mass, and is not coupled mechanically to the generator (as in a ceramic cartridge), a properly adjusted stylus follows the groove more faithfully while requiring less tracking force (the downward pressure on the stylus).

Moving iron and induced magnet types (ADC being a well known example) have a moving piece of iron or other ferrous alloy is coupled to the cantilever (instead of a magnet), while a permanent, bigger magnet is over the coils, providing the necessary magnetic flux.

Moving Coil (MC) cartridges

Diagram of moving coil cartridge, showing essential parts

The MC design is again a tiny electromagnetic generator, but (unlike an MM design) with the magnet and coils reversed: the coils are attached to the stylus, and move within the field of a permanent magnet. The coils are tiny and made from very fine wire.

Since the amount of windings that can be supported in such armature is small, the output voltage level is corresponsingly small. The resulting signal is only a few hundred microvolts, and thus more easily swamped by noise, induced hum, etc. Thus it is more challenging to design a preamplifier with the extremely low noise inputs needed for moving-coil cartridge, therefore a "step up transformer" is sometimes used instead.

However, there are available many "high output" moving coil cartridges that have output levels similar to MM cartridges.

Moving coil cartridges are extremely small precision instruments and are therefore generally expensive, but are frequently preferred by audiophiles due to a subjectively better performance.

Moving Micro Cross (MMC) cartridges

The MMC design was invented and patented by Bang & Olufsen. The MMC cartridge is variation of the Moving Iron (MI) design. Magnets and coils are stationary while a micro cross moves with the stylus, thereby varying the distances between the arms of the cross and the magnets. It is claimed that the MMC design allows for superior channel separation, since each channel's movements appear on a separate axis.

Moving Magnet vs. Moving Coil debate

Moving magnet cartridges are more commonly found at the 'lower-end' of the market, while the 'higher-end' tends to be dominated by moving coil designs. The debate as to whether MM or MC designs can ultimately produce the better sound is often heated and subjective. The distinction between the two is often blurred by cost and design considerations - i.e. can an MC cartridge requiring another step-up amplification outperform well made MM cartridges that need simpler front-end stages? Every now and then a design comes along to re-open this debate.

  • MC cartridges offer very low inductance and impedance, which means that the effects of capacitance (in the cable that goes from the cartridge to the preamp) are negligible, unlike MM cartridges, which comparatively sport very high inductance and impedance. In the latter, cable capacitance can negatively affect the flatness of frequency response and linearlity of phase response. This would account for a sonic advantage to MC types.
  • It is generally believed that MC cartridges sport lower moving masses. However quality MM cartridges are able to sport lower moving masses than the best MC cartridges. For example, the state-of-the-art Technics EPC-100CMK4 with 0.055mg of effective tip mass, of moving magnet design. Comparatively, the popular Denon DL-301 moving coil cartridge has an effective tip mass of 0.270mg.
  • To discriminate cartridges by engine (MC vs MM) overlooks the fact that the stylus tip shape and cantilever have a significant influence in the sound, and this may account for even more sonic differences than the engine type used.

"London Decca" Cartridges

The Decca phono cartridges were a unique design, with fixed magnets and coils. The stylus shaft was composed of the diamond tip, a short piece of soft iron, and an L-shaped cantilever made of non-magnetic steel. Since the iron was placed very close to the tip (within 1 mm), the motions of the tip could be tracked very accurately. Decca engineers called this "positive scanning". Vertical and lateral compliance was controlled by the shape and thickness of the cantilever. Decca cartridges had a reputation for being very musical; however early versions required more tracking force than competitive designs - making record wear a concern.

External links


Wikimedia Foundation. 2010.

Игры ⚽ Нужен реферат?

Look at other dictionaries:

  • Cartridge — can refer to: *Cartridge (electronics), a module to be inserted into a larger piece of equipment *4 track cartridge, an analogue music storage format popular from the late 1950s to the early 1970s *8 track cartridge, an analogue music storage… …   Wikipedia

  • Cartridge (electronics) — In various types of electronic equipment, a cartridge can refer one method of adding different functionality or content (e.g. a video game cartridge), or a method by which consumables may be replenished (e.g. an ink cartridge for a printer). The… …   Wikipedia

  • Magnetic tape data storage — uses digital recording on to magnetic tape to store digital information. Modern magnetic tape is most commonly packaged in cartridges and cassettes. The device that performs actual writing or reading of data is a tape drive. Autoloaders and tape… …   Wikipedia

  • Magnetic Video — logo Magnetic Video was a home video/audio duplication service established by Andre Blay in 1968 and based in Farmington Hills, Michigan. In 1977 it became the first corporation to release theatrical motion pictures onto Betamax and VHS… …   Wikipedia

  • Magnetic tape — 7 inch reel of ¼ inch wide audio recording tape, typical of consumer use in the 1950s–70s. Magnetic tape is a medium for magnetic recording, made of a thin magnetizable coating on a long, narrow strip of plastic. It was developed in Germany,… …   Wikipedia

  • Magnetic tape sound recording — Klaudia Wilde from the German WDR radio archive with a broadcast tape from 1990 The use of magnetic tape for sound recording originated around 1930. Magnetizable tape revolutionized both the radio broadcast and music recording industries. It did… …   Wikipedia

  • cartridge — Synonyms and related words: Gramophone, PA, PA system, Victrola, audio sound system, audiophile, backing, ball cartridge, bibliofilm, binaural system, bipack, bitch box, black and white film, blank cartridge, bullhorn, cartouche, cassette,… …   Moby Thesaurus

  • cartridge — UK [ˈkɑː(r)trɪdʒ] / US [ˈkɑrtrɪdʒ] noun [countable] Word forms cartridge : singular cartridge plural cartridges 1) a small container with ink inside that you put into a printer or pen 2) a small metal tube containing a bullet and a substance that …   English dictionary

  • cartridge — n. 1 a case containing a charge of propelling explosive for firearms or blasting, with a bullet or shot if for small arms. 2 a spool of film, magnetic tape, etc., in a sealed container ready for insertion. 3 a component carrying the stylus on the …   Useful english dictionary

  • cartridge — noun Etymology: alteration of earlier cartage, modification of Middle French cartouche Date: 1626 a case or container that holds a substance, device, or material which is difficult, troublesome, or awkward to handle and that usually can be easily …   New Collegiate Dictionary

Share the article and excerpts

Direct link
Do a right-click on the link above
and select “Copy Link”