Columbia Accident Investigation Board

Columbia Accident Investigation Board
Memorial emblem for the three U.S. human space flight accidents. Translation: "To The Stars, Through Adversity – Always Exploring"

The Columbia Accident Investigation Board (CAIB) was convened by NASA to investigate the destruction of the Space Shuttle Columbia during STS-107 upon atmospheric re-entry on February 1, 2003. In addition to determining the cause of the accident, the panel also recommended changes that should be made to increase the safety of future shuttle flights. The CAIB released its final report on August 26, 2003.

Contents

Major findings

The board found both the immediate physical cause of the accident and also what it called organizational causes.

Immediate cause of the accident

82 seconds after launch a large piece of foam insulating material from the external tank broke free and struck the leading edge of the shuttle's left wing, damaging the protective carbon heat shielding panels. This damage allowed super-heated gases to enter the wing structure during re-entry into the Earth's atmosphere and caused the destruction of the Columbia.

Organizational cause of the accident

The problem of debris shedding from the external tank was well known and had caused shuttle damage on every prior shuttle flight. The damage was usually, but not always, minor. Over time, management gained confidence that it was an acceptable risk. The board found that this should not have happened.

The shuttle organization is very large, and decision makers cannot embody all information. Organizational mechanisms are responsible for properly informing and guiding decision makers. The report placed equal weight on organizational failings as the cause of the accident.

Echoes of Challenger

One board member, Dr. Sally Ride, served on both the CAIB panel and Rogers Commission and noted remarkable similarities between the two tragedies. She questioned why the shuttle was allowed to continue flying with known problems that were, eventually, catastrophic.

Since no machine is perfect, the problem comes down to identifying which known problems are an acceptable risk and which are not. In these two examples, shedding foam and failing o-rings, the organization failed to react correctly to the seriousness of the problem: in both cases, whereas engineers recognized the seriousness of the problem, NASA management dismissed both the evidence and the engineers' expertise and ultimately decided to continue with the mission, with catastrophic results.

To illustrate the organizational problems of safety awareness, Richard Feynman attached a personal appendix to the Rogers Commission Report. It is equally relevant to the CAIB report. In it, he wrote: "It appears that there are enormous differences of opinion as to the probability of a failure with loss of vehicle and of human life. The estimates range from roughly 1 in 100 to 1 in 100,000. The higher figures come from the working engineers, and the very low figures from management. What are the causes and consequences of this lack of agreement? … we could properly ask, 'What is the cause of management's fantastic faith in the machinery?'"

The CAIB report found these same misperceptions by management and concluded that they contributed to the accident. Both reports also examined the ability of schedule pressures to influence safety-related design decisions.

The ultimate responsibility for the failure of Challenger as well as Columbia must reside with the decisionmakers - in this case, NASA executives who decided to ignore, dismiss, or minimize the testimony of their engineering experts.

Board recommendations

The board made 29 specific recommendations to NASA to improve the safety of future shuttle flights. These recommendations include:

  • Foam from external tank should not break free
  • Better pre-flight inspection routines
  • Increase quality of images available of shuttle during ascent and on-flight
  • Recertify all shuttle components by the year 2010
  • Establish an independent Technical Engineering Authority that is responsible for technical requirements and all waivers to them, and will build a disciplined, systematic approach to identifying, analyzing, and controlling hazards throughout the life cycle of the Shuttle System.

In the meantime, only two further Space Shuttle missions are allowed to be flown before the implementation of these recommendations.

Shuttle program since the CAIB report

After the CAIB report came out, NASA implemented all recommended changes and flew its first post-Columbia mission in 2005. As part of the CAIB recommendations, the Shuttle carried a 50-foot inspection boom attached to the robot arm, which was used within 24 hours of launch to check the orbiter for damage. As all but one of the post-Columbia missions are concentrated on the International Space Station, primarily to provide a "safe haven" in the event an orbiter is damaged beyond the normal repair methods, NASA (smarting from a critical report that the STS-107 crew could have been rescued using the Space Shuttle Atlantis) implemented a STS-3xx contingency mission program that can launch a rescue orbiter on short notice, similar to the Skylab Rescue that was planned during the Skylab program.

NASA retired the Space Shuttle fleet on July 21, 2011 after completing the ISS and the final flight and subsequent landing of Space Shuttle Atlantis. The Shuttle's replacement, Orion, was to have consisted of an Apollo-derived spacecraft launched on the Ares I rocket, which would use a Space Shuttle Solid Rocket Booster as its first stage. Orion would not face the dangers of either an O-ring failure (due to the presence of a launch escape system[1]) or shedding foam (as the spacecraft will be launched in a stack configuration). In addition to ferrying crews to the ISS, the Orion spacecraft was to (as part of Project Constellation) allow NASA to return to the Moon[2]. President Obama signed the NASA Authorization Act 2010 on October 11 which officially brought the Constellation program to an end, replacing it with the Space Launch System (SLS) and Multi-Purpose Crew Vehicle (MPCV) programs to develop the launch vehicle and spacecraft to enable human exploration missions beyond low-Earth orbit.[3]

Board members[4]

Chairman of the board

Board members

Board support

  • Ex-Officio Member: Lt. Col. Michael J. Bloomfield, NASA Astronaut
  • Executive Secretary: Mr. Theron M. Bradley, Jr., NASA Chief Engineer

Partial list of additional investigators and CAIB support staff

  • Col Timothy Bair
  • Col. Jack Anthony
  • Dr. James P. Bagian
  • Lt. Col. Richard J. Burgess
  • Thomas L. Carter
  • Dr. Dwayne A. Day
  • Major Tracy Dillinger
  • Thomas L. Foster
  • CDR Mike Francis
  • Howard E. Goldstein
  • Lt. Col Patrick A. Goodman
  • Lt. Matthew E. Granger
  • Ronald K. Gress
  • Thomas Haueter
  • Dr. Daniel Heimerdinger
  • Dennis R. Jenkins
  • Christopher Kirchhoff
  • Dr. Gregory T. A. Kovacs
  • John F. Lehman
  • Jim Mosquera
  • Gary Olson
  • Gregory Phillips
  • David B. Pye
  • Lester A. Reingold
  • Donald J. Rigali
  • Dr. James. W. Smiley
  • G. Mark Tanner
  • Lt. Col. Wade J. Thompson
  • Bob Vallaster
  • Lt. Col. Donald J. White
  • Dr. Paul D. Wilde
  • LCDR Johnny R. Wolfe Jr.
  • Richard W. Russell
  • Dr. Robert E. Green, Jr.

See also

  • Apollo 204 Review Board
  • Rogers Commission

References

Sources

External links


Wikimedia Foundation. 2010.

Игры ⚽ Нужно сделать НИР?

Look at other dictionaries:

  • Accident de la navette spatiale Columbia — ██████████50  …   Wikipédia en Français

  • Accident de la navette spatiale Challenger — 28°38′24″N 80°16′48″O / 28.64, 80.28 …   Wikipédia en Français

  • Columbia disaster — ▪ United States history  breakup of the U.S. space shuttle orbiter Columbia on Feb. 1, 2003, that claimed the lives of all seven astronauts (astronaut) on board just minutes before it was to land at the Kennedy Space Center in Florida.  Columbia …   Universalium

  • Columbia (navette spatiale) — Pour les articles homonymes, voir Columbia. Columbia OV 102 …   Wikipédia en Français

  • Explosion de la navette spatiale Columbia — Accident de la navette spatiale Columbia ██████████ …   Wikipédia en Français

  • Space Shuttle Columbia — Columbia OV 102 Space Shuttle Columbia launches on STS 109(HST 3B)to repair the Hubble Space telescope.This was the final sucessful mission of Columbia before STS 107 OV designation OV 102 Country …   Wikipedia

  • Space Shuttle Columbia disaster — For further information about Columbia s mission and crew, see STS 107. STS 107 mission patch The Space Shuttle Columbia disaster occurred on February 1, 2003, when shortly before it was scheduled to conclude its 28th mission, STS 107, the Space… …   Wikipedia

  • Navette Columbia — Navette spatiale Columbia Pour les articles homonymes, voir Columbia. Columbia {{{abrev}}} …   Wikipédia en Français

  • Navette Spatiale Columbia — Pour les articles homonymes, voir Columbia. Columbia {{{abrev}}} …   Wikipédia en Français

  • Navette spatiale Columbia — Pour les articles homonymes, voir Columbia. Columbia {{{abrev}}} …   Wikipédia en Français

Share the article and excerpts

Direct link
Do a right-click on the link above
and select “Copy Link”